Munchkin Gas-Fired Hot Water Boiler Installation Manual download pdf (Page 11)

10

GAS-FIRED HEATER Installation Manual

PART 4: PREPARE MUNCHKIN CONTENDER

(CONTINUED)

D. INSTALLATION STEPS

1) Prior to lifting the Munchkin Contender

Heater onto the wall, use the enclosed

template to level and locate the 2 primary

screws (#12 x 3" (3/16" x 3") round head

tapping screw leaving about 1/4" under the

screw head to the wall surface to allow for

access to the keyway slot which is located in

the back of the heater panel. It is extremely

important that the line on the template is level

when locating the first 2 screws. Failure to do

so will result in an uneven or out of level

installation.

2) Remove the Munchkin Contender cover and

locate the 2 keyway slots over the screws,

then lower the heater onto the smallest part

of the keyway slot.

3) Once the heater is mounted on the first 2

screws, finish tightening the first two screws to

the back panel, then install the 6 additional

screws of the same size to the back panel

holes. This will provide additional strength and

support to the Munchkin Contender Heater.

C. MUNCHKIN CONTENDER

WALL MOUNTING INSTRUCTIONS

The wall must be vertically plumb and capable of

carrying the weight of the Munchkin Contender and

its related components.

The building frame (studs) must be 16" on cen-

ter. If not, you must use 1/2" minimum plywood

24" x 48", fastened with at least (14) #12 x 3"

(3/16" x 3") round head tapping screws to the

frame of the building to provide proper support

for the boiler. Alternate methods of mounting

must not be used. (ex. toggle bolts, hollow wall

anchors) or any other fastener other than #12 x

3" (3/16" x 3") round head tapping screws.

WARNING

The wall must be capable of carrying the weight

of the heater and its related components. The

weights of the heater are approximately:

MC-50- 71 lbs.

MC-80- 74 lbs.

MC-99-

MC-120-

]]

84 lbs.

Failure to comply with above could result in

severe personal injury, death or substantial

property damage.

WARNING

This heater is heavy and awkward to lift. It is

recommended and safer to install the heater

with two people. Use caution as to not drop the

heater which could cause personal injury. Verify

that the heater is securely mounted before

leaving the heater unsupervised.

CAUTION

If the Munckin Contender is not vertically

plumb, improper and unsatisfactory operation

may occur. This will cause excessive

condensation build-up causing unnecessary

maintenance and nuisance fault codes.

1 2 ... 6 7 8 9 10 11 12 13 14 15 16 ... 67 68

Comments to this Manuals

No comments